Safety Recall
#18V665000 A loss of drive can disable the vehicle unexpectedly, increasing the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2017-2018 Gillig Low Floor transit buses equipped with certain Allison transmission hybrid drive units. The pressure switches on these Drive Units may fail, possibly resulting in a loss of drive.
Safety Recall
#18V789000 Loose cage bolts may result in the bus rolling away when in the park position or a loss of braking ability if the service brake air pressure is lost while moving. Either condition may increase the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2013-2018 Gillig Low Floor transit buses equipped with disk brakes. The spring cage bolts on the air brakes may not be sufficiently tightened, reducing the effectiveness of the parking brake.
Safety Recall
#18V511000 The mismatched flashing may confuse other drivers, increasing the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2012-2018 Gillig Low Floor vehicles. The front and rear turn signals on these vehicles may flash at different rates, potentially confusing other drivers of the vehicle's intention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment.
Safety Recall
#18V418000 The reduced visibility of the turn signals can increase the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment.
Safety Recall
#19V193000 A loss of headlights can reduce the driver's ability to see, increasing the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.
Safety Recall
#19V451000 If the tempered glass roof hatch shatters, glass fragments may fall onto passengers, increasing the risk of an injury.
Technical Summary Gillig LLC (Gillig) is recalling certain 2018-2019 Low Floor vehicles equipped with a certain batch of glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.
Safety Recall
#19V059000 If the ball stud is insufficiently tightened, the ball stud may wear, resulting in reduced handling and stability, increasing the risk of crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2016-2018 Low Floor buses. The ball stud of the steering system draglink may not have been properly tightened.
Safety Recall
#20V239000 If the fuel system ruptures from exposure to heat, there may be an increased risk of injury.
Technical Summary Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing.
Safety Recall
#20V342000 If the rear suspension lower control rod fails, the bus may have reduced handling and stability, increasing the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.
Safety Recall
#20V392000 A loss of power steering assist may increase the risk of crash.
Technical Summary Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
Safety Recall
#20V179000 With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Technical Summary Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
Safety Recall
#21V352000 A fuel leak in the presence of an ignition source increases the risk of a fire.
Technical Summary Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Safety Recall
#22V276000 The engine may be started unexpectedly, increasing the risk of injury to anyone nearby the engine compartment during maintenance operations.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.