Safety Recall
#19V193000 A loss of headlights can reduce the driver's ability to see, increasing the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.
Safety Recall
#19V451000 If the tempered glass roof hatch shatters, glass fragments may fall onto passengers, increasing the risk of an injury.
Technical Summary Gillig LLC (Gillig) is recalling certain 2018-2019 Low Floor vehicles equipped with a certain batch of glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.
Safety Recall
#20V239000 If the fuel system ruptures from exposure to heat, there may be an increased risk of injury.
Technical Summary Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing.
Safety Recall
#20V342000 If the rear suspension lower control rod fails, the bus may have reduced handling and stability, increasing the risk of a crash.
Technical Summary Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.
Safety Recall
#20V392000 A loss of power steering assist may increase the risk of crash.
Technical Summary Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
Safety Recall
#20V179000 With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Technical Summary Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
Safety Recall
#21V352000 A fuel leak in the presence of an ignition source increases the risk of a fire.
Technical Summary Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Safety Recall
#22V436000 An unexpected switch to neutral can cause a loss of vehicle propulsion and increase the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor electric transit buses. The EV resolver cable connector may experience a loss of electrical connectivity, unexpectedly switching from Drive to Neutral with no warning.
Safety Recall
#22V276000 The engine may be started unexpectedly, increasing the risk of injury to anyone nearby the engine compartment during maintenance operations.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.
Safety Recall
#22V548000 A battery short circuit increases the risk of a fire.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor vehicles equipped with Cummins BP74E battery packs. The battery packs may develop a coolant leak internally, causing the battery pack to short circuit.
Safety Recall
#23V740000 A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2019-2023 Low Floor transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Safety Recall
#25V076000 A monitor that detaches and falls from the ceiling increases the risk of injury.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.