Safety Recall
#23V809000 Rear drive axle failure can result in a loss of vehicle control and increase the risk of a crash or injury.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2023 Low Floor vehicles. An inadequate amount of lubricant in the rear axle hubs may cause failure of the rear drive axles.
Safety Recall
#23V635000 A detached driveshaft can cause a loss of vehicle control, increasing the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2022-2023 Low Floor transit buses. The driveshaft fasteners may have been improperly tightened after service repairs, allowing the driveshaft to detach.
Safety Recall
#23V740000 A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2019-2023 Low Floor transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Safety Recall
#23V812000 An incorrect fuse may overheat and increase the risk of a fire.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2021-2023 Low Floor vehicles. The rearview mirror electric adjustment system may have been manufactured with an incorrect fuse.
Safety Recall
#23V075000 A damaged steering system can result in a loss of vehicle handling and control, increasing the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2022-2023 Low Floor transit and shuttle buses. Incompatible steering system draglink parts may have been installed during the vehicle assembly process, potentially resulting in long-term damage of the steering system.
Safety Recall
#24V921000 A missing odometer reading could lead to an unintended delay in critical safety-related maintenance, potentially impairing the safe operation of the vehicle and increasing the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2023 Low Floor diesel-hybrid transit buses. During vehicle operations in full electric vehicle (EV) mode, the odometer will not display accumulated mileage. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays.
Safety Recall
#24V959000 Failure to alert the operator to a power cable issue can increase the risk of injury by electrical shock.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor style transit buses. The high voltage electric air compressor may not be connected to the High Voltage Interlock Loop (HVIL). Therefore, the HVIL cannot detect a loose or disconnected compressor power cable.
Safety Recall
#24V514000 A loose steering shaft can cause a complete loss of steering control, increasing the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The steering spline shaft fasteners may have been improperly tightened, allowing the steering spline shaft to loosen.
Safety Recall
#24V958000 Failure of the fire suppression system can increase the risk of injury during a fire.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2021-2024 Low Floor style transit buses. The fire suppression relay cable may be damaged, chafing against the mounting bolt, and fail.
Safety Recall
#24V390000 A fuel leak in the presence of an ignition source increases the risk of a fire. Additionally, a lack of fuel can cause an engine stall, increasing the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2023 Low Floor buses equipped with Cummins L9 diesel engines with part number D563027BX03. Insufficient crimping may allow the remote fuel filter hoses to disconnect and leak, decreasing fuel supply to the engine.
Safety Recall
#25V203000 A short circuit increases the risk of a fire. In addition, the battery contactors may open suddenly and cause a loss of drive power, increasing the risk of a crash.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The high voltage batteries may have loose hardware that can fall inside the battery pack and create a short circuit.
Safety Recall
#25V076000 A monitor that detaches and falls from the ceiling increases the risk of injury.
Technical Summary Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.