Safety Recall
#21V226000 A hole in the diaphragm may cause an air leak, causing the parking brake to engage and increasing the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2021 International LT and International RH vehicles. The spring inside the spring brake chamber may allow the pressure plate to shift and wear a hole through the diaphragm.
Safety Recall
#21V079000 An unexpected engine shutdown can increase the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2018-2021 International LoneStar and 2017-2021 International LT vehicles. The battery ground cable ring terminal at the frame connecting point may break, resulting in a loss of electrical power and unintended engine shutdown without warning.
Safety Recall
#21V281000 Connecting rod failure may cause a stall, increasing the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2019-2021 International LT and RH trucks. The wrist pin may crack and cause connecting rod failure.
Safety Recall
#21V227000 Unintended spring brake application may occur, increasing the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2021 International LT, RH, MV, and HV vehicles equipped with Bendix pressure switches. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems.
Safety Recall
#21V112000 A detached flywheel can cause loss of drive power, increasing the risk of a crash. Additionally, driveline pieces may be ejected from the engine compartment, increasing the risk of injury.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2021 International LT vehicles equipped with a Cummins X15 engine. The capscrews that attach the flywheel to the crankshaft may have been improperly torqued, allowing the flywheel to detach.
Safety Recall
#22V164000 A damaged battery cable can cause an electrical short, increasing the risk of a fire.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2018-2023 International LT vehicles equipped with a 1500W Purkeys inverter system. The positive battery cable may be incorrectly routed, causing it to chafe on the side skirt frame and become damaged.
Safety Recall
#22V691000 Connecting rod failure can cause an engine shutdown, increasing the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2018-2021 International HV, 2018-2020 International HX, 2018-2021 International LT and International RH vehicles. The connecting rod wrist pin may crack, resulting in connecting rod failure.
Safety Recall
#22V546000 Excessively hot battery ground cables may cause personal injury during battery maintenance repairs. In addition, a battery post that separates from the battery can result in an engine stall without warning, increasing the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2018-2021 International LoneStar and 2016-2021 International LT vehicles. The cables that connect the batteries to the vehicle frame may become excessively hot, and in some cases, cause battery post separation.
Safety Recall
#23V220000 A vehicle that unexpectedly slows to idle speed on the roadway can increase the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2021-2024 International LT and RH trucks. The engine control module (ECM) may be unresponsive to throttle pedal application, which can cause the vehicle to unexpectedly slow to idle speed on the road.
Safety Recall
#23V370000 An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2021-2024 International HV, HX, LoneStar, LT, MV, eMV, and RH trucks, and IC Bus CE, 2021-2023 IC Bus RE, and 2022-2023 IC Bus TC Commercial Buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
Safety Recall
#23V353000 Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Technical Summary Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment.
Safety Recall
#24V818000 Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.
Technical Summary International Motors, LLC (International) is recalling certain 2021-2024 Lonestar, 2021-2025 RH, HV, MV, LT, HX, and 2022 PROSTAR vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Safety Recall
#25V817000 Safety systems that depend on the ECU, such as Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System, may have diminished or lost functionality, increasing the risk of a crash.
Technical Summary International Motors, LLC (International) is recalling certain 2016-2023 Lonestar, 2018 8600, 2018-2023 LT, 2021-2026 MV, 2022-2023 RH, 2023-2026 HX, and 2025-2026 HV vehicles. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.