Safety Recall
#10V177000 THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.
Technical Summary DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.
Safety Recall
#11V505000 A BRAKE FLUID LEAK MAY REDUCE BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Technical Summary DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 9, 2004, THROUGH JANUARY 2, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES, HYDRAULIC BRAKES, AND A FUEL WATER SEPARATOR. THE FUEL LINE GOING FROM THE FUEL WATER SEPARATOR TO THE ENGINE MAY RUB ON THE HYDRAULIC BRAKE LINES POTENTIALLY RESULTING IN BRAKE FLUID LEAK.
Safety Recall
#11V201000 INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
Technical Summary CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.
Safety Recall
#11V222000 IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
Technical Summary DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Safety Recall
#11V503000 AN ELECTRIC FAULT OR SHORT CIRCUIT OF AN UN-FUSED POWER CABLE MAY RESULT IN A VEHICLE FIRE.
Technical Summary DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM APRIL 5, 2004 THROUGH DECEMBER 26, 2005. THE PASS-THROUGH POWER CABLE CONNECTIONS LOCATED BEHIND THE DRIVER'S SIDE KICK PANEL MAY CORRODE POTENTIALLY RESULTING IN AN ELECTRIC FAULT OR SHORT CIRCUIT.
Safety Recall
#15V425000 If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Technical Summary Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2004 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 non-school buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Safety Recall
#15V565000 If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Technical Summary Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Safety Recall
#15V432000 If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.
Technical Summary Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2013 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 school buses manufactured from February 5, 2001, through May 29, 2012. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.
Safety Recall
#17V454000 In the event of a crash, an unsecured wheelchair may increase the risk of injury.
Technical Summary Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 transit buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.
Safety Recall
#17V453000 In the event of a crash, an unsecured wheelchair may increase the risk of injury.
Technical Summary Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 school buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.
Safety Recall
#18V083000 In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Technical Summary Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf